All prices on www.aprtuned.co.uk are listed in GBP and pertain to the UK market only. 
www.aprtuned.co.uk is your Number 1 source for APR products & is operated from London, UK.

Browse through the categories to find your car and the available products.

APR’s TTE420 Turbo ECU Upgrade (for K04 Cars)

« back
Home > Volkswagen > Golf & GTI Mk5

APR’s TTE420 Turbocharger ECU Upgrade is designed for use with the The Turbo Engineer's TTE420 turbocharger and produces an asphalt-shredding 400 HP on 98 octane fuel, and up to 442 HP using race fuel! Expect lightning fast response coupled with smooth daily driving and a much broader power band that pulls all the way to redline!

Using multiple vehicles across the world and in house, APR’s team of Calibration and Electrical Engineers mastered the Bosch MED9 engine management system to work seamlessly with the upgraded TTE420 turbocharger unit. All critical aspects of the vehicle’s platform were taken into consideration and monitored through APR’s proprietary engine management logging tools to levels often not seen elsewhere in this industry. Through proper mapping, the ECU fully understands the hardware changes and operates correctly. As such torque delivery is smooth and flat, avoiding compressor surge, limitations in the factory fueling system, and limiting stress on the factory transmission. Cam phasing operations are optimized, aiding in turbocharger spool, while allowing the engine to breathe more efficiently at higher engine speeds. Under various operational modes, lambda, ignition advance, requested torque, boost pressure levels and more were painstakingly optimized to produce maximum power without resorting to risky calibration shortcuts.

APR Calibration Report
Stage Fuel Max HP Max TQ Max HP Gain Over Stock Max TQ Gain Over Stock
- Max increases are based on APR's actual measured stock values and not those reported by VAG.
- Reported wheel figures measured using APR's in-house Dynapack Dynamometer with a US Spec MK6 Golf R in FWD mode with TTE420 turbocharger, APR Cast Downpipe, APR Intake System and APR Intercooler, using SAEJ1349 correction and an average of multiple runs. Crank figures are estimated based on the measured wheel figures. Results may vary depending upon environmental conditions, vehicle, transmission, vehicle health, operating conditions, temperatures, fuel grade, dyno type, dyno setup, other variables and other modifications.
Stock As Reported by VAG 95 RON 220 - 272 HP 243 - 258 FT-LBS
Stock As Measured by APR 98 RON 271 HP 260 FT-LBS
APR TTE420 Turbocharger ECU Upgrade 95 RON 392 HP 401 FT-LBS +131 HP @ 5,300 RPM +141 FT-LBS @ 3,900 RPM
APR TTE420 Turbocharger ECU Upgrade 98 RON 400 HP 413 FT-LBS +144 HP @ 5,250 RPM +152 FT-LBS @ 3,900 RPM
APR TTE420 Turbocharger ECU Upgrade 104 RON 419 HP 431 FT-LBS +166 HP @ 5,250 RPM +171 FT-LBS @ 4,950 RPM
APR TTE420 Turbocharger ECU Upgrade 108 RON 442 HP 449 FT-LBS +188 HP @ 5,350 RPM +190 FT-LBS @ 5,000 RPM

Requirements and Recommendations

  • Turbocharger:
    A TTE420 Turbocharger from The Turbo Engineers with the 'stage 2 APR wastegate actuator spring' is required.
  • Intake:
    A high flow quality intake system that replaces the factory air box is required.
  • Exhaust:
    A high flow downpipe is required but the catback exhaust may remain unmodified.
  • Intercooler:
    An intercooler upgrade is required.
  • High Pressure Fuel Pump:
    A high pressure fuel pump upgrade is required.
  • Low Pressure Fuel Pump:
    A low pressure fuel pump upgrade is required.
  • Fuel Rail Relief Valve:
    A 155 bar fuel rail pressure relief valve is required.
  • Valve Springs:
    Upgraded valve springs may be required if valve float is exhibited.
  • Spark Plugs:
    APR's software is designed for use with NGK BKR8EIX spark plugs gapped to 0.022" ±0.002" or 0.55mm ±0.05mm with a change interval of 10-15,000 mi or 16-24,000 km
  • Transmission:
    The APR TCU Upgrade is highly recommended.
Application Guide
Vehicle Engine Transmission
Audi A1 2.0 TFSI All
Audi S3 (MKII) 2.0 TFSI All
Audi TTS (MKII) 2.0 TFSI All
KTM X-Bow 2.0T All
Seat Leon Cupra / Cupra R / Supercopa (MKII) 2.0T FSI All
Volkswagen Golf R / ED30 / ED35 / Pirelli 2.0T FSI All
Volkswagen Polo R WRC 2.0T FSI All
Volkswagen Scirocco R 2.0T FSI All

NOW: £909.00

Customer Reviews
Write an online review and share your thoughts with other shoppers!


Phone: (+44) 0208 681 0208 Address: APR Tuned, 40 Haling Road, South Croydon, Surrey, CR2 6HS

Copyright © 1997 - Present Day: APR Tuned. All Right Reserved

VW®, Volkswagen®, Golf®, GTI®, R32®, Rabbit®, Jetta®, GLI®, Passat®, Passat CC®, Toureg®, Tiguan®, Beetle®, EOS®, A3®, S3®, A4®, S4®, RS4®, A5®, S5®, Q5®, A6®, S6®, RS6®, Q7®, TT®, A8®, S8®, R8®, Porsche®, 996®, 997®, 911®, Carrera®, Cayman®, Boxster®, Cayenne® are trademarks of Volkswagen AG, Audi AG, and Porsche AG. While we try to keep everything current, we cannot be held responsible for errors in pricing on this web site as prices do change. All prices are in GBP PLUS VAT and are applicable to UK only.